THE SIMULATION OF GRANULAR PARTICLE ON DRY AND MOISTURIZED POROUS HORIZONTAL SURFACES

Dewi Muliyati; Dadan Sumardani; Fauzi Bakri; Handjoko Permana; Erfan Handoko; Ni Larasati Kartika Sari

doi:10.21009/SPEKTRA.061.08

Authors

Dewi Muliyati Physics Education Department, Universitas Negeri Jakarta, Jakarta, Indonesia
Dadan Sumardani Teachers College, National Chiayi University, Taiwan
Fauzi Bakri Physics Education Department, Universitas Negeri Jakarta, Jakarta, Indonesia
Handjoko Permana Physics Education Department, Universitas Negeri Jakarta, Jakarta, Indonesia
Erfan Handoko Physics Department, Universitas Negeri Jakarta, Jakarta, Indonesia
Ni Larasati Kartika Sari Physics Department, Universitas Nasional, Jakarta, Indonesia

DOI:

https://doi.org/10.21009/SPEKTRA.061.08

Keywords:

dry surface, granular simulation, moisturized surface, porous horizontal surfaces

Abstract

Simulations were carried out to visualize the ratio of granular attachment to porous surfaces. This simulation uses a uFlex three-dimensional simulation using three sizes of porous surface systems in the condition of the smallest human pores and the most extensive human pores and the condition of wet skin and dry skin. Each system was tested using five granular particle sizes according to the range of the makeup granules’ size to determine the optimal adhesive. The results show that the number of cosmetic granular particles entering the porous surface system is directly proportional to the porous surface volume and moisture and inversely proportional to the granular cosmetic size. The larger the cosmetic granular used, the less granular enters the pore.

References

[1] S. Rémond et al., “Simulation of the packing of granular mixtures of non-convex particles and voids characterization,” Granul. Matter, vol. 10, pp. 157-170, 2008.
[2] A. Sufian et al., “Pore shapes, volume distribution and orientations in monodisperse granular assemblies,” Granul. Matter, vol. 17, no. 6, pp. 727-742, 2015.
[3] M. Xu et al., “DEM Simulation of The Undrained Shear Behavior of Sand Containing Dissociated Gas Hydrate,” Granul. Matter, vol. 18, no. 4, pp. 79–91, 2016.
[4] X. Ting et al., “Study of the Characteristics of the Flow Regimes and Dynamics of Coarse Particles in Pipeline Transportation,” Powder Technol, vol. 347, pp. 148-158, 2019.
[5] M. Ariane et al., “Wall collision and drug-carrier detachment in dry powder inhalers : Using DEM to devise a sub-scale model for CFD calculations,” Powder Technol, vol. 334, pp. 65-75, 2018.
[6] Y. Yao, “Granular Computing : Past, Present and Future,” RSKT 2008 Rough Sets Knowl. Technol, vol. 5009, pp. 27-28, 2016.
[7] O. Stenzel et al., “Quantitative Structural Analysis of Simulated Granular Packings of Non-spherical Particles,” Granul. Matter, vol. 16, no. 4, pp. 457-468, 2014.
[8] F. Flament et al., “Facial skin pores : a multiethnic study,” Clin. Cosmet. Investig. Dermatol, vol. 8, pp. 85-93, 2015.
[9] P. S. Prestes et al., “Particle size and morphological characterization of cosmetic emulsified systems by Optical Coherence Tomography ( OCT ),” Brazilian J. Pharm. Sci, vol. 52, no. 2, pp. 273-280, 2016.
[10] Horiba, “A Guidebook To Particle Size Analysi,” Irvine, USA: HORIBA Insruments, 2017.
[11] Horiba, “Particle Size Analysis of Cosmetics,” Irvine, USA: HORIBA Instruments, 2007.
[12] R. Costa, L. Santos, “Delivery systems for cosmetics - From manufacturing to the skin of natural antioxidants,” Powder Technol, vol. 322, pp. 402-416, 2017.
[13] J. B. Holyoke, W. C. Lobitz, “Histologic Variations in the Structure of Human Eccrine Sweat Glands,” J. Invest. Dermatol, vol. 18, no. 2, pp. 147-167, 1952.
[14] C. R. Harding, “The Stratum Corneum: Structure and Function in Health and Disease,” Dermatol. Ther, vol. 17, pp. 6-15, 2004.
[15] A. Donev, “Improving the Density of Jammed Disordered Packings Using Ellipsoids,” Science, vol. 303, no. 5660, pp. 990-993, 2004.
[16] P. Erdos, R. L. Graham, “On Packing Squares with Equal Squares,” J. Comb. Theory, vol. 19, pp. 119-123, 1975.
[17] Y. G. Stoyan, G. N. Yaskov, “Packing Identical Spheres into a Cylinder,” Intl. Trans. Op. Res, vol. 17, pp. 51-70, 2010.
[18] Y. Jiao et al., “Optimal Packings of Superballs,” Phys. Rev. E, vol. 79, no. 041309, pp. 1-12, 2009.
[19] L. Boissieux et al., “Simulation of Skin Aging and Wrinkles with Cosmetics Insight,” Comput. Animat. Simul, vol. 2000, pp. 15-27, 2000.
[20] C. Li et al., “Physically-Based Simulation of Cosmetics via Intrinsic Image Decomposition with Facial Priors,” IEEE Trans. Pattern Anal. Mach. Intell, vol. 40, no. 10, pp. 1-15, 2018.
[21] W. Steiling et al., “Principles for The Safety Evaluation of Cosmetic Powders,” Toxicol. Lett, vol. 297, pp. 8-18, 2018.
[22] S. Torquato, Y. Jiao, “Dense Packings of The Platonic and Archimedean Solids,” Nature, vol. 460, pp. 876-879, 2009.
[23] F. A. L. Dullien, “Porous Media: Fluid Transport and Pore Structure,” San Diego: Academic Press, 1992.
[24] I. Smalley, “Simple Regular Sphere Packings in Three Dimensions,” Math. Mag, vol. 36, no. 5, pp. 295-300, 1963.
[25] T. Igarashi et al., “The Appearance of Human Skin,” New York: Columbia University, 2005.
[26] W. D. James et al., “Andrews’ Diseases of the Skin: Clinical Dermatology,” Philadelphia: Saunders, 2005.
[27] Desmos Graphing Calculator [Computer software], Retrieved from https://www.desmos.com/calculator, 2020.
[28] GeoGebra 3D Calculator [Computer software], Retrieved from https://www.geogebra.org/classic#3d, 2020.
[29] J. George, B. Thomas, “Calculus, Thirteenth,” Boston: Pearson Education, 2014.
[30] Z. D. Draelos, “The Science Behind Skin Care: Moisturizers,” J. Cosmet. Dermatol, vol. 17, no. 2, pp. 138-144, 2018.
[31] D. Rosso et al., “The Clinical Relevance of Maintaining The Functional Integrity of The Stratum Corneum in Both Healthy and Disease Affected Skin,” J Clin Aesthet Dermatol, vol. 4, no. 9, pp. 22-42, 2011.
[32] Z. D. Draelos, “Cosmeceuticals: Efficacy and Influence on Skin Tone,” Dermatol Clin, vol. 32, pp. 137-143, 2014.
[33] Z. D. Draelos, “Cosmeceuticals: Undefined, Unclassified, and Unregulated,” Clin Dermatol., vol. 27, no. 5, pp. 431-434, 2009.
[34] Z. D. Draelos, “Cosmetics, Categories, and The Future,” Dermatol Ther, vol. 25, no. 3, pp. 223-228, 2012.
[35] A. Sethi et al., “Moisturizers: The Slippery Road,” Indian J Dermatol, vol. 61, no. 3, pp. 279-287, 2016.
[36] I. Nicander et al., “Baseline Electrical Impedance Measurements at Various Skin Sites-related to Age and Gender,” Ski. Res. Technol, vol. 3, pp. 252-258, 1997.
[37] T. S. Spencer, “Dry Skin and Skin Moisturizers,” Clin. Dermatol, vol. 6, no. 3, pp. 24-28, 1988.
[38] Z. D. Draelos, “Therapeutic Moisturizers,” Dermatol Clin, vol. 18, pp. 597-607, 2000.
[39] T. C. Flynn et al., “Dry Skin and Moisturizers,” Clin. Dermatol, vol. 19, pp. 387-392, 2001.
[40] S. Purnamawati et al., “The Role of Moisturizers in Addressing Various Kinds of Dermatitis: A Review,” Clin. Med. Res, vol. 15, no. 3, pp. 75-87, 2017.
[41] A. Varshney et al., “Estimating the Number of Unit Spheres Inside a Larger Sphere,” Chapel Hill: University of North Carolina, 1994.
[42] D. Muliyati et al., “The 3-D visualization of the granular particle on various diameter porous surfaces,” J. Phys. Conf. Ser., vol. 1402, no. 7, p. 077026, 2019.
[43] D. Muliyati et al., “The granular buoyant force in a two-dimensional intruder-particles bed system,” AIP Conference Proceedings, vol. 2169, p. 040005, 2019.
[44] D. Muliyati et al., “Simulation of granular in two dimensions: The effect of particle velocity on rigid wall boundary,” MATEC Web Conf. vol. 197, p. 02001, 2018.